IEC_TS_63066-2017.pdf

IEC TS 63066 Edition 1.0 2017-03 TECHNICAL SPECIFICATION Low-v oltage docking connectors for remov able energy storage units IEC T S 63066:2017-03(en)THIS PUBLICATION IS COPYRIGHT PROTECTED Copyright 2017 IEC,Geneva,Switzerland All rights reserved.Unless otherwise specified,no part of this publication may be reproduced or utilized in any form or by any means,electronic or mechanical,including photocopying and microfilm,without permission in writing from either IEC or IECs member National Committee in the country of the requester.If you have any questions about IEC copyright or have an enquiry about obtaining additional rights to this publication,please contact the address below or your local IEC member National Committee for further information.IEC Central Office Tel.:+41 22 919 02 11 3,rue de Varemb Fax:+41 22 919 03 00 CH-1211 Geneva 20 infoiec.ch Switzerland www.iec.ch About the IEC The International Electrotechnical Commission(IEC)is the leading global organization that prepares and publishes International Standards for all electrical,electronic and related technologies.About IEC publications The technical content of IEC publications is kept under constant review by the IEC.Please make sure that you have the latest edition,a corrigenda or an amendment might have been published.IEC Catalogue-webstore.iec.ch/catalogue The stand-alone applica tion for consulting the entire bibliogr aphical informa tion on IEC International Standar ds,Technical Specifica tions,Technical Reports and other documents.Av ailable for PC,Mac OS,Android Tablets and iPad.IEC publications search-www.iec.ch/searchpub The adv anced sear ch enables to find IEC publications by a var iety of cr iter ia(refer ence number,text,technica l committee,).It also gives infor ma tion on pr ojects,replaced and w ithdraw n publications.IEC Just Published-webstore.iec.ch/justpublished Stay up to da te on all new IEC publications.Just Published details all new publica tions released.Av ailable online and also once a month by email.Electropedia-www.electropedia.org The w or lds leading online dictionary of electronic and electrical terms containing 20 000 terms and definitions in English and Fr ench,w ith equiv alent terms in 16 additional languages.Also know n as the Inter national Electr otechnical Vocabulary(IEV)online.IEC Glossary-std.iec.ch/glossary 65 000 electrotechnical terminology entries in English and Fr ench extracted fr om the Terms and Definitions clause of IEC publica tions issued since 2002.Some entr ies hav e been collected from ear lier publications of IEC TC 37,77,86 and CISPR.IEC Customer Serv ice Centre-webstore.iec.ch/csc If you w ish to giv e us your feedback on this publication or need fur ther assistance,plea se contact the Customer Ser v ice Centre:csciec.ch.IEC TS 63066 Edition 1.0 2017-03 TECHNICAL SPECIFICATION Low-v oltage docking connectors for remov able energy storage units INT ERNAT IONAL ELECT ROT ECHNICAL COMMISSION ICS 29.120.30 ISBN 978-2-8322-4124-0 Registered t rademark of the Internat ional Electrotechnica l Commission Warning!Mak e sure that you obtained this publication from an authorized distributor.2 IEC TS 63066:2017 IEC 2017 CONTENTS FOREWORD.5 INTRODUCTION.7 1 Scope.8 2 Normative references.8 3 Terms and definitions.9 4 General.11 4.1 General requirements.11 4.2 General notes on tests.11 4.3 General construction.11 4.4 Visual examination tests.12 4.5 Cable to be used.12 4.6 Voltage and current for test purposes.12 4.7 Type of accessories.12 5 Standard ratings.13 6 Classification of accessories.13 7 Marking.15 8 Dimensions.16 9 Protection against electric shock.16 10 Provision for earthing.17 11 Terminals and terminations.18 12 Interlocks.18 13 Resistance to ageing of rubber and thermoplastic material.19 14 General construction.19 15 Construction of accessories.19 16 Degrees of protection.19 17 Insulation resistance and dielectric strength.19 18 Mechanical endurance.19 19 Temperature rise.20 20 Mechanical strength.20 21 Screws,current-carrying parts and connections.20 22 Creepage distances,clearances and distances through sealing compound.20 23 Resistance to heat,to fire and to tracking.21 24 Conditional short-circuit current withstand test.21 25 Electromagnetic compatibility.21 26 Dynamic mechanical severities.21 26.1 Minimum degree of dynamic mechanical severities.21 26.2 Appropriate functionality.22 27 Electrical endurance.22 27.1 General requirements for accessories.22 27.2 Temperature burden for accessories.22 27.3 Damp heat for accessories.23 27.4 Contact resistance.23 IEC TS 63066:2017 IEC 2017 3 28 Climatic endurance for contacts.23 28.1 General requirements for contacts.23 28.2 Thermal change for contacts.24 28.3 Dry heat for contacts.24 28.4 Corrosion resistance for contacts.24 28.5 Damp heat for contacts.24 28.6 Functionality for contacts.24 28.7 Shocks for contacts.24 29 Climatic endurance for bodies.25 29.1 General requirements for bodies.25 29.2 Dry heat for bodies.25 29.3 Cold resistance f