IEC_TS_62763-2013.pdf

IEC/TS 62763 Edition 1.0 2013-12 TECHNICAL SPECIFICATION Pilot function through a control pilot circuit using PWM(pulse width modulation)and a control pilot wire IEC/TS 62763:2013(E)Copyrighted material licensed to BR Demo by Thomson Reuters(Scientific),Inc.,,downloaded on Nov-27-2014 by James Madison.No further reproduction or distribution is permitted.Uncontrolled when printed.THIS PUBLICATION IS COPYRIGHT PROTECTED Copyright 2013 IEC,Geneva,Switzerland All rights reserved.Unless otherwise specified,no part of this publication may be reproduced or utilized in any form or by any means,electronic or mechanical,including photocopying and microfilm,without permission in writing from either IEC or IECs member National Committee in the country of the requester.If you have any questions about IEC copyright or have an enquiry about obtaining additional rights to this publication,please contact the address below or your local IEC member National Committee for further information.IEC Central Office Tel.:+41 22 919 02 11 3,rue de Varemb Fax:+41 22 919 03 00 CH-1211 Geneva 20 infoiec.ch Switzerland www.iec.ch About the IEC The International Electrotechnical Commission(IEC)is the leading global organization that prepares and publishes International Standards for all electrical,electronic and related technologies.About IEC publications The technical content of IEC publications is kept under constant review by the IEC.Please make sure that you have the latest edition,a corrigenda or an amendment might have been published.Useful links:IEC publications search-www.iec.ch/searchpub The advanced search enables you to find IEC publications by a variety of criteria(reference number,text,technical committee,).It also gives information on projects,replaced and withdrawn publications.IEC Just Published-webstore.iec.ch/justpublished Stay up to date on all new IEC publications.Just Published details all new publications released.Available on-line and also once a month by email.Electropedia-www.electropedia.org The worlds leading online dictionary of electronic and electrical terms containing more than 30 000 terms and definitions in English and French,with equivalent terms in additional languages.Also known as the International Electrotechnical Vocabulary(IEV)on-line.Customer Service Centre-webstore.iec.ch/csc If you wish to give us your feedback on this publication or need further assistance,please contact the Customer Service Centre:csciec.ch.Copyrighted material licensed to BR Demo by Thomson Reuters(Scientific),Inc.,,downloaded on Nov-27-2014 by James Madison.No further reproduction or distribution is permitted.Uncontrolled when printed.IEC/TS 62763 Edition 1.0 2013-12 TECHNICAL SPECIFICATION Pilot function through a control pilot circuit using PWM(pulse width modulation)and a control pilot wire INTERNATIONAL ELECTROTECHNICAL COMMISSION V ICS 43.120 PRICE CODE ISBN 978-2-8322-1281-3 Registered trademark of the International Electrotechnical Commission Warning!Make sure that you obtained this publication from an authorized distributor.Copyrighted material licensed to BR Demo by Thomson Reuters(Scientific),Inc.,,downloaded on Nov-27-2014 by James Madison.No further reproduction or distribution is permitted.Uncontrolled when printed.2 TS 62763 IEC:2013(E)CONTENTS FOREWORD.4 INTRODUCTION.6 1 Scope.7 2 Normative references.7 3 Control pilot circuit.7 3.1 General.7 3.2 Typical pilot electric equivalent circuit.8 3.3 Simplified pilot electric equivalent circuit.9 3.4 Other requirements.9 4 Requirements for parameters.10 5 Test procedures for immunity of EV supply equipment to wide tolerances on the pilot wire and the presence of high frequency data signals on the pilot wire.25 5.1 General.25 5.2 Constructional requirements of the EV simulator.25 5.3 Test procedure.25 5.4 Test list Oscillator frequency and generator voltage test.26 5.5 Duty cycle test.27 5.6 Pulse wave shape test.27 5.7 Sequences diagnostic normal charge cycle.27 5.8 Open earth wire test.29 5.9 Test of short circuit values of the voltage.29 5.10 Example of a test simulator of the vehicle(informative).29 5.11 Optional hysteresis test.31 5.11.1 General.31 5.11.2 Test sequence for hysteresis between states B and C.32 5.11.3 Test sequence for hysteresis between states C-E,D-E.32 5.11.4 Test sequence for hysteresis between states C-D.32 Figure 1 Typical control pilot electric equivalent circuit.8 Figure 2 Simplified control pilot electric equivalent circuit.9 Figure 3 State machine diagram for typical control pilot.15 Figure 4 State machine diagram for simplified control pilot.15 Figure 5 Normal operation cycle.27 Figure 6 Simplified control pilot cycle.28 Figure 7 Optional charge cycle test.29 Figure 8 Example of a test circuit(EV simulator).30 Table 1 Maximum allowable carrier signal voltages on pilot wire.10 Table 2 Control pilot circuit parameters(see Figures 1 and 2).10 Table 3 Vehicle control pilot circuit values and parameters.11 Table 4 System states detected by th