_STP_1434-2002.pdf

STP 1434 The Use of Glass in Buildings VaIerie L.Block,editor ASTM Stock Number:STP1434 ASTM International 100 Barr Harbor Drive PO Box C700 West Conshohocken,PA 19428-2959 Printed in the U.S.A.Library of Congress Cataloging-in-Publication Data ISBN:Symposium on the Use of Glass in Buildings(1st:2002:Pittsburgh,Pa.)The use of glass in buildings/edited by Valerie L.Block.p.cm.-ASTM special technical publication;1434 Includes bibliographical references and index.ASTM stock number:STP1434.ISBN 0-8031-3458-4 1.Glass construction-Congresses.2.Glazing-Congresses.3.Safety glass-Congresses.I.Block,Valerie L.,1951-II.Title.TH1560.S96 2002 691.6-dc21 2002038238 Copyright?9 2002 ASTM International,West Conshohocken,PA.All rights reserved.This material may not be reproduced or copied,in whole or in part,in any printed,mechanical,electronic,film,or other distribution and storage media,without the written consent of the publisher.Photocopy Rights Authorization to PhOtocopy items for internal,personal,or educational classroom use,or the internal,personal,or educational classroom use of specific clients,is granted by ASTM International(/LTM)provided that the appropriate fee is paid to the Copyright Clearance Center,222 Rosewood Drive,Danvers,MA 01923;Tel:978-750-8400;online:http:/ Review Policy Each paper published in this volume was evaluated by two peer reviewers and at least one edi-tor.The authors addressed all of the reviewers comments to the satisfaction of both the technical editor(s)and the ASTM International Committee on Publications.To make technical information available as quickly as possible,the peer-reviewed papers in this publication were prepared camera-ready as submitted by the authors.The quality of the papers in this publication reflects not only the obvious efforts of the authors and the technical editor(s),but also the work of the peer reviewers.In keeping with long-standing publication practices,ASTM International maintains the anonymity of the peer reviewers.The ASTM International Committee on Publications acknowledges with appreciation their dedication and con-tribution of time and effort on behalf of ASTM International.Printed in Bridgeport,NJ December 2002 Foreword The Symposium on The Use of Glass in Buildings was held in Pittsburgh,Pennsylvania on 14 April,2002.ASTM International Committee E06 on Performance of Buildings served as its sponsor.The symposium chair of this publication was Valerie L.Block.Contents Overview vii SESSION I:QUALITY ISSUES ASTM C 1036:Does It Work for Field Inspections of Surface Blemishes?-TED W.MAZULA AND IVAR HENNINGS Codes and Standards Affecting Glass in Buildings:The U.S.and Beyond-VALERIE L.BLOCK The Impact of Serf.Cleaning Glass-CHRISTOPHER J.BARRY AND THOMAS ODAY PC.Based Stress Measuring System for On-line Quality Control of Tempered and Heat.Strengthened GlasS-ALEX S.REDNER 8 20 26 SESSION II PERFORMANCE ASSESSMENTS In-Situ Dew-Point Measurement to Assess Life Span of Insulating Glass Units-GEORGE R.TOROK,WERNER LICHTENBERGER,AND ALLAN MAJOR Evaluation of the Condensation Resistance Rating as Determined Using the NFRC 500 Progedure-DAN1EL J.WISE AND BIPIN V.SHAH 35 49 SESSION III:GLASS DESIGN Structural Performance of Laminated Glass Made with a Stiff Interlayer-STEPHEN J.BENNISGN,C.ANTHONY SMITH,ALEX VAN DUSER,AND ANAND JAGOTA Development of Design Methodology for Rectangular Glass Supported on Three Sides to Resist Lateral Uniformity Distributed Loads-MOSTAFA M,EL-SHAM!AND H.SCOTT NORVILLE Wind Load Resistance of Large Trapezoidal Glass Lites-H.scoyr NORVILLE,MOSTAFA M.EL-SHAMI,RYAN JACKSON,AND GEORGE JOHNSON 57 66 79 Window Glass Design Software-STEPHEN M.MORSE A Thermal Stress Evaluation Procedure for Monolithic Annealed Glass-W.LYNN BEASON AND A.WILLIAM LINGNELL 90 105 SESSION IV:GLASS IN HURRICANES Retrofitting Commercial Structures with Laminated Glass to Withstand Hurricane Effects-PAUL E.BEERS,MARK A.PILCHER,AND JEFFREY C.SCIAUDONE Testing of Annealed Glass With Anchored-Film Glass Retention Systems for Fallout Protection after Thermal Stress Cracking-BRUCE S.KASKEL,JOHN E.PEARSON,MARK K.SCHMIDT,AND ROGER E.PELLETIER 121 131 SESSION V:GLASS FOR FIRE SAFETY AND SECURITY The Advantages of Glazing in Overall Security Strategy-MiCHAEL BETTEN AND HENRI BERUBE The Relationship Between Sprinkler Systems and GlasS-JERRY RAZWICK Design Procedure for Blast.Resistant Laminated Glass-H.SCOTT NORVILLE AND EDWARD J.CONRATH Index 147 153 159 171 Overview This book represents the work of numerous authors at the first Symposium on the Use of Glass in Buildings,April 14,2002,Pittsburgh,PA.Architectural glass was the broad focus for this symposium.Papers and presentations were targeted to deliver information the user may find useful related to the quality,design,use,and performance of architectural glass.The symposium had a broad focus that incorporated a variety of glass-related topics.Em-phasis on glass design was also a key feature to the symposium.The papers contain